This bike has been sitting for several years, So when the customer pulled it out some attention was needed.

First we had a charging problem; So we went threw the charging system,

1. Tested battery- which had a dead cell
2. Tested stator output
3. Tested wire for shorts & grounds & for good Earthing
4. Tested regulator / rectifier for possible bad diodes

Now were getting ready to start & run the engine to do a dynamic system test under load. This is when we find out....

Number 2 & 3 cylinder carbs are flooded so bad it's coming back through the carb, Well we knew a carb clean & sync was in order based on the time it sat So here we go.

 

Well carbs, jets, bowls & passages cleaned, time for reassembly..







O check out this before & after side-by-side



So all good re-installed and now she runs!.. presto!

Now to finish the charging system....... and we're charging.